Ford E-450 Super Duty

The L shaped bracket that supports the RV hydraulic/motor assembly for the auto leveling system has failed. The weld between two pieces of steel that makes up the bracket has failed. When the bracket fails the assembly is supported temporarily by electrical wires and hydraulic hoses. If it fails further and drags the road or separates completely, there is a possibility of fire under the vehicle and/or death or injury to other drivers on the road. There other safety recalls for this exact…

Description When your vehicle is in reverse gear, the vehicles exterior sounder backup alarm may only produce an intermittent warning sound or may be inoperative and produce no warning sound. Safety Risk A backup alarm that does not emit sound may fail to alert pedestrians or other road users of a reversing vehicle, increasing the risk of a crash or injury. Remedy Parts are available to repair your vehicle. Ford Motor Company has authorized your dealer to repair the wiring connection at…

Parking Brake The Sticker on this U-Haul 15 foot Truck says, Engage the Parking Brake before turning off the Engine, otherwise UNCONTROLLED OPERATION OF VEHICLE may occur.. I pulled on the Parking Brake as the Sticker warned. With my foot off the Gas Pedal, at about 25 - 30 MPH the U-Haul Steered way to the right by itself, and drove onto the Right Curb. This was quite Frightening and Unexpected. Then it happened again later that day at just about 30 MPH, again with my foot off the Gas…

Airbag module casing is cracked.

The contact rented a 2016 U-Haul E450. The contact stated that while in the parking lot and placing the vehicle in drive, the contact tapped on the accelerator pedal, then when the brakes were applied and the vehicle suddenly accelerated. The contact removed her foot from the brake, and it continued to accelerate and crashed into a parked U-Haul truck. There were no reported injuries, fire, airbag deployment, or police report filed. It was unknown if there were any warning lights illuminated.…

Air bag cover separating

Airbag cover is separating

Lifters in engine is going out. Ford has made a TSBs for repair because lifters and camshaft was made by a third party and they are defect. Here is Technical Service Bulletin (TSB 25-2200). Vehicle is available for inspection. It was put at risk because vehicle could loose power at any time and potential crash into another car. The problem has been reproduced in 4 different Ford vehicles. Has not been inspected by manufacturer or others. No warning lights were present.

Engine camshaft and lifters failed. Truck is at a Ford dealer. Engine could fail in the middle of the road, causing an accident. This is our eighth vehicle with the same issue taken to a ford dealer in the past year. A little knocking noise started that quickly turned into a loud knocking/rattling noise. No lights came on the truck.

Sped up a bit today get in front of my husband and as I did i noticed that all of a sudden I lost power. I wasn't able to go faster than 40 mph, and I wasn't able to go into gear.